2021 Hyundai Santa Fe Problems

Half of the owners who gave a mileage had the problem by about 17,000 miles.

What to check before you buy

• Drive it from cold if you can. Shifts should be smooth in every gear, including reverse.
• Feel for slipping (revs rise without the car speeding up), shudder at low speed and a delay when you put it in gear.
• Listen for whining, which is a common CVT complaint, and clunks when you go from drive to reverse.
• If it has 4WD or AWD, engage it on the test drive and ask when the transmission and differential fluids were last changed.

Tools that help

What owners said

On September 20, 2026, my 2021 Hyundai Santa Fe Calligraphy suffered sluggish acceleration while operating on a public roadway due to an internal dual-clutch transmission (DCT) failure. The Malfunction indicator light illuminated, and a diagnostic scan revealed stored history code P1C2D03, indicating a total breakdown of the…Owner complaint, filed 2026

The contact owns a 2021 Hyundai Santa Fe. The contact stated that while driving approximately 5-30 MPH, the transmission failed to shift properly, and the vehicle lost motive power. The engine warning light was illuminated. The contact stated that the failure was a recurring failure. The contact stated that the vehicle was repaired under…Owner complaint, filed 2026, at 78,000 miles

Half of the owners who gave a mileage had the problem by about 28,000 miles.

What to check before you buy

• Ask the seller not to warm the car up, and start it cold. Listen for ticking, knocking or a rough idle in the first minute.
• Pull the oil dipstick and the oil cap. Low oil, a gasoline smell or a milky film on the cap are reasons to walk away or get an inspection.
• Plug in an OBD2 scanner. Stored or pending codes matter, and so do readiness monitors that show "not ready", which usually means the codes were cleared right before the sale.
• Ask for oil change records. A gap in the records on a model known for engine complaints is a negotiating point at minimum.

Tools that help

What owners said

The contact owned a 2021 Hyundai Santa Fe. The contact stated that while his wife was driving 50 MPH, the vehicle unexpectedly caught on fire. The contact's wife became aware that the radio was inoperable before the failure. Additionally, the contact’s wife’s eyes were irritated, and there was a hot, harsh odor which grew stronger very…Owner complaint, filed 2026, at 58,000 miles

My vehicle loses power on the highway intermittently. I had my car set on cruise control at 55 and with no other vehicle in front of me the speed decreased to 45. It frequently sputters going up hills. My car has had 4 oil leaks.Owner complaint, filed 2026

What to check before you buy

• Test every switch: windows, locks, mirrors, seat heaters, the screen, the backup camera, Bluetooth and every USB port.
• Watch the dash at startup. Every warning light should come on briefly and then go out.
• Have the battery and charging system tested. A weak alternator or battery drain shows up here.

Tools that help

What owners said

The rearview backup camera system malfunctioned. The camera was replaced under a safety recall on my 2021 Hyundai Santa Fe. Within four days of the recall repair, the camera continued to fail intermittently, displaying a blank/black screen and not providing a rearview image when the vehicle was placed in reverse. The vehicle is available…Owner complaint, filed 2026

Horn failure, confirmed by Hyundai dealership. No warning or indication of failure. Went to use horn in a safety situation when I needed it, and it was non-functional. A huge safety risk for myself and other drivers on the road. In doing research, this is a known manufacturer defect, with most owners having to replace low and high horns…Owner complaint, filed 2025

Half of the owners who gave a mileage had the problem by about 21,000 miles. Parts named most: Automatic emergency braking (15), Warnings (6).

What to check before you buy

• Where it is safe, try the adaptive cruise and lane keeping on the test drive and watch for sudden braking or warnings with nothing there.
• Check the windshield in front of the camera and the bumper sensors for cracks, chips or poor repairs.
• Ask whether the windshield has been replaced. The camera has to be recalibrated afterward, and many shops skip it.

Tools that help

What owners said

The contact owns a 2021 Hyundai Santa Fe. The contact stated that while in reverse(R), the rear-view camera displayed a distorted pixelated image on the screen. The dealer and the manufacturer were notified of the failure and stated that there were no recalls associated with the VIN. Upon investigation, the contact discovered NHTSA…Owner complaint, filed 2026, at 40,000 miles

My rear back up camera intermitting stops working. I can shift into reverse sometimes and the camera does not come on at all, other times the screen blinks and other times the screen has green lines and glitchy lines. The camera will also come on while I'm DRIVING forwardOwner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 10,000 miles.

What to check before you buy

• Check every light: headlights on low and high, fog lights, brake lights, turn signals and reverse lights.
• Run the wipers on every speed with washer fluid, and run the defroster front and back.

Tools that help

What owners said

The windshield wipers intermittently stop working. This has been occurring for 2 years and the 5dealership cannot find an issue because they always work when the car is in for service. They also now want to charge a diagnostic fee each time it's in since the car is no longer under warrantyOwner complaint, filed 2026

My 2021 Hyundai Santa Fe (VIN starting with 5NM) began experiencing a significant failure of the air conditioning system during its third year of ownership. The vehicle developed a persistent refrigerant leak that now requires annual recharges to remain functional. Multiple inspections suggest the failure is due to a porous evaporator…Owner complaint, filed 2026

What to check before you buy

• Smell around the engine bay and under the rear of the car for raw fuel.
• On the test drive, accelerate firmly from a stop and up a grade. Stumbling, surging or a flashing check engine light are red flags.
• Fuel pump recalls are common. Check this exact VIN for open recalls before you buy.

Tools that help

What owners said

The door to the gas tank is a push door which is temperamental. I can be at the pump and push the door to pop it open and it won't. I'm at the point where I have to pop my gas tank open before I even get to the gas station because to pull up to the pump and not be able to put gas in the tank is a waste of time. There is no lever to flip…Owner complaint, filed 2026

When I try to open the fuel cover it wont' open. I have to lock and unlock my car, sometimes up to 10 times, to get the fuel fill door to open. This eventually is going to leave me stranded somewhere stranded. Some of my same year and model are covered under recall for this issue by when I call Hyundai my VIN is not covered. I would like…Owner complaint, filed 2026

What to check before you buy

• On the test drive, press the gas gently and firmly. The response should be smooth with no lag or surge.
• Set the cruise control, then use resume and cancel to make sure each one works.

Tools that help

What owners said

The vehicle will accelerate unexpectedly without using the accelarator. Usually this occurs when releasing the brakes and on a slight incline.. To date no injuries or damage has occurred due to this. My dealer has not reproduced this defect as far as I know. This vehicle has nor been inspected by the daeler or insurance reps to my…Owner complaint, filed 2023

My check engine light came on, and my car was also feeling "sluggish" and slow to accelerate. I scheduled a service appointment at my local dealer 4 days later. At the appointment, the technician stated everything checked out okay and the check engine light was likely an "anomaly" or "outlier" but otherwise nothing to be concerned about…Owner complaint, filed 2026

What to check before you buy

• The pedal should feel firm and the car should stop straight without pulling, grinding or a pulsing pedal.
• The ABS and stability control lights should go out after startup and stay out.
• Look through the wheels at the rotors. A deep lip on the edge means brakes are due soon, which is a fair thing to negotiate on.

Tools that help

What owners said

The contact owns a 2021 Hyundai Santa Fe. The contact stated that while his wife was driving at various speeds, she had to depress the brake pedal to the floorboard to stop the vehicle. The contact stated no warning light was illuminated. The contact called the local dealer and made them aware of the failure. The vehicle was not…Owner complaint, filed 2023, at 58,800 miles

Was coming off an exit on the interstate and started slowing down. My brakes act like they didn’t want to work. Grinding and the pedal was twitching under my foot. The car stopped thankfully, but then all Linda of lights came on the my dash and will not go off. And 3 warning come up!Owner complaint, filed 2026

What to check before you buy

• Pull out and latch every seat belt, and let each one retract on its own.
• Try every seat adjuster, and watch for a passenger air bag "off" light when an adult is in the seat.

Tools that help

What owners said

The seat belt is incredibly slow to retract. Most times I need to help it along. I've tried pulling it out to check for kinks (none there) and tried cleaning it but it still won't retractOwner complaint, filed 2025

The driver side seat belt crosses at my neck. I have adjusted it as much as it will adjust and it still cuts into my neck. I am very concerned that if I am in an accident it will choke me or even decapitate me. In addition it is very uncomfortable but I am mostly concerned about the safety issue. I have not brought the issue to the…Owner complaint, filed 2024

What to check before you buy

• Look underneath with a flashlight. Utah road salt is hard on frames, brake lines and the bottoms of doors.
• Open and close every door, the hood and the liftgate, and lock and unlock each one.
• Use a paint thickness gauge and compare panels. A panel that reads very differently from the rest has likely been repaired.

Tools that help

What owners said

The contact filed the complaint on behalf of the contact's mother. The contact owned a 2021 Hyundai Santa Fe. The contact stated that while the contact's mother was driving at an undisclosed speed, the vehicle was crashed into by an oncoming vehicle. The other vehicle crashed into the front passenger's side close to the front bumper…Owner complaint, filed 2025

The Brow Glass between the top of the windshield and the sun roof, alligator cracked following by a complete crack and breakage along the full width of the glass.Owner complaint, filed 2023

What to check before you buy

• The air bag (SRS) light should come on at startup and go out within a few seconds. If it stays on, the system may not work in a crash.
• Air bag recalls are some of the most serious. Check this exact VIN for open recalls and get proof any recall work was done.

Tools that help

What owners said

The contact owns a 2021 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the controls on the steering wheel became inoperable. In addition, the air bag warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with clock spring failure. The contact was informed…Owner complaint, filed 2025, at 60,000 miles

The contact owns a 2021 Hyundai Santa Fe. The contact stated while driving at various speeds with an occupant in the passenger’s side front seat, the air bag light off message was displayed. The vehicle was taken to the local dealer, where it was diagnosed that a software update was needed. The vehicle was repaired, but the failure…Owner complaint, filed 2024, at 16,000 miles

What to check before you buy

• Turn the wheel lock to lock while parked and listen for groaning, clicking or binding.
• On a straight road the car should track straight with the wheel centered and no loose feeling.
• A power steering warning on the dash, even briefly, deserves a mechanic’s look before you buy.

Tools that help

What owners said

While driving the crash avoidance emergency braking came on out of nowhere, and the steering locked up. I was driving on a straight and level roadway with no vehicles in front of me when suddenly the whole dash lit up with warning lights and the car, a 2021 Hyundai Santa Fe, came to a emergency stop, the steering wheel was shaking and…Owner complaint, filed 2022

What to check before you buy

• Read the four-digit DOT date on each tire. Tires older than about six years should be replaced, whatever the tread looks like.
• Check tread depth on all four. On AWD vehicles all four tires should match.
• The tire pressure light should go out after startup.

Tools that help

What owners said

Ever since I have purchased these tires I have been experiencing extreme violent vibration between 60 to 75 Mi an hour on the highway at first I wondered if something was wrong with the balance on the tire so I had them checked at the dealership twice and then I went to another dealership because the problem continue and had them checked…Owner complaint, filed 2025