2024 Ford Expedition Problems

Parts named most: Warnings (11), Blind spot detection (6).

What to check before you buy

• Where it is safe, try the adaptive cruise and lane keeping on the test drive and watch for sudden braking or warnings with nothing there.
• Check the windshield in front of the camera and the bumper sensors for cracks, chips or poor repairs.
• Ask whether the windshield has been replaced. The camera has to be recalibrated afterward, and many shops skip it.

Tools that help

What owners said

While leaving a parking lot the vehicle was pulling out a parking spot in reverse, as the vehicle changed from reverse to drive, teh vehicle randomly started accelerating without cause, the gas pedal was not initiated and there was no pedal influence at all. The car had an internal computer issue and started to sort through the cruise…Owner complaint, filed 2026

Intermittent warning of front camera collision / braking malfunction. Usualy less then 10 seconds but on one occassion persisted for about 10 minutes. Has been to dealership for investigation without resolution. Happened last on 7/16/2026. Arrived at dealership withing 20 minutes, they were able to call up the alert on there service…Owner complaint, filed 2026

What to check before you buy

• Test every switch: windows, locks, mirrors, seat heaters, the screen, the backup camera, Bluetooth and every USB port.
• Watch the dash at startup. Every warning light should come on briefly and then go out.
• Have the battery and charging system tested. A weak alternator or battery drain shows up here.

Tools that help

What owners said

Started vehicle for first drive of the day and noticed the digital instrument cluster failed to display any information. The screen remained blank although the backlight was on. Turned the vehicle off and on, performed a reset, disconnected battery for more than an hour before reconnecting, checked fuses, etc., but the display did not…Owner complaint, filed 2026

I am filing this complaint regarding Ford Safety Recall 25S49 (NHTSA Campaign Number 25V315). My vehicle is a 2024 Ford Expedition Max, VIN [XXX] . The Ford pass app and the Ford recall site both show the remedy for the recall as "Available", but when I contact my dealer (Maxwell Ford in Austin, TX) they say that the repair cannot be…Owner complaint, filed 2025

What to check before you buy

• The pedal should feel firm and the car should stop straight without pulling, grinding or a pulsing pedal.
• The ABS and stability control lights should go out after startup and stay out.
• Look through the wheels at the rotors. A deep lip on the edge means brakes are due soon, which is a fair thing to negotiate on.

Tools that help

What owners said

The 2024 Ford expedition brakes was not working at the time of the accident, we later found that there was a recall on the brakes. PMA companies is the TPA for the Victaulic Companies, please see accident description below: Insured driver states she Pulled in driveway and was trying to park vehicle. Driver hit the brakes all the way down…Owner complaint, filed 2025

I am the owner of a 2024 Ford Expedition, purchased new in March 2024. I am writing to formally report multiple instances of complete brake failure, which pose a significant safety risk. The most recent incident occurred on [XXX], at approximately [XXX], while I was driving northbound on [XXX] in Cupertino, California, with my wife and…Owner complaint, filed 2025

What to check before you buy

• On the test drive, press the gas gently and firmly. The response should be smooth with no lag or surge.
• Set the cruise control, then use resume and cancel to make sure each one works.

Tools that help

What owners said

My wife tried to move my expedition from spot to another in our parking lot During that maneuver the gas pedal assembly broke down and the car in high speed created some personal and property damages I have the part handy and ready for inspection up on request The insurance knows about it And I had a police report No warning prior to the…Owner complaint, filed 2025

The contact owns a 2024 Ford Expedition. The contact stated that while making a right turn, the vehicle accelerated independently and rear-ended a city bus. The vehicle came to a stop from the impact. None of the air bags deployed. There were no injuries sustained. The "Pre-Collision Assist not available" and the "Adaptive Cruise not…Owner complaint, filed 2025, at 15,263 miles

What to check before you buy

• Check every light: headlights on low and high, fog lights, brake lights, turn signals and reverse lights.
• Run the wipers on every speed with washer fluid, and run the defroster front and back.

Tools that help

What owners said

The contact owns a 2024 Ford Expedition. The contact stated that while operating the vehicle, there was an abnormal rattling sound coming from the roof of the vehicle. The vehicle was taken to the local dealer, who determined that the panoramic sunroof brackets had fractured and needed to be replaced. The brackets were replaced; however…Owner complaint, filed 2025, at 10,000 miles

When driving my entire window switch controller unit stopped working on the driver's side. At the time the window was partially down. After research I came to find this has been a common problem with the switch unit in Expeditions, F150s, Explorers. This is a safety issue as you cannot get the window to roll up which allows rain and snow…Owner complaint, filed 2025

What to check before you buy

• Ask the seller not to warm the car up, and start it cold. Listen for ticking, knocking or a rough idle in the first minute.
• Pull the oil dipstick and the oil cap. Low oil, a gasoline smell or a milky film on the cap are reasons to walk away or get an inspection.
• Plug in an OBD2 scanner. Stored or pending codes matter, and so do readiness monitors that show "not ready", which usually means the codes were cleared right before the sale.
• Ask for oil change records. A gap in the records on a model known for engine complaints is a negotiating point at minimum.

Tools that help

What owners said

Incident happened 06/26/2026. My wife was driving with our 4 kids down the highway to family event. My wife smelled a funny odor coming from the vents and was going to drive to the next exit and then noticed smoke. At that moment she wasn’t sure where the smoke was coming from. She put the hazards on and started pulling off to the…Owner complaint, filed 2026

This is a report of a recurring, life-safety defect involving unintended vehicle movement in a 2024 Ford Expedition. The vehicle has experienced two separate incidents where it was placed in 'Park,' remained stationary for 13-30 seconds, and then began driving itself backward without driver intervention or throttle input. Incident 1…Owner complaint, filed 2026

What to check before you buy

• Drive it from cold if you can. Shifts should be smooth in every gear, including reverse.
• Feel for slipping (revs rise without the car speeding up), shudder at low speed and a delay when you put it in gear.
• Listen for whining, which is a common CVT complaint, and clunks when you go from drive to reverse.
• If it has 4WD or AWD, engage it on the test drive and ask when the transmission and differential fluids were last changed.

Tools that help

What owners said

Transmission failure. Vehicle has failed to accelerate and then failed to move at all. Still under warranty and no codes shown. Vehicle left immobile on interstate due to intermittent transmission failure. Initial repair was not sufficient as issue has returned. No solutions for additional repair to address safety issue.Owner complaint, filed 2026

At 715 miles on the odometer, the driver's side rear axle became detached from the wheel hub bearing, causing a loss of power while driving. Dealer states this was a manufacturing defect as the axle retaining bolt was cross-threaded and not properly seated.Owner complaint, filed 2025

What to check before you buy

• Look underneath with a flashlight. Utah road salt is hard on frames, brake lines and the bottoms of doors.
• Open and close every door, the hood and the liftgate, and lock and unlock each one.
• Use a paint thickness gauge and compare panels. A panel that reads very differently from the rest has likely been repaired.

Tools that help

What owners said

Hood striker fasteners failed allowing hood to separate from striker at highway speed resulting in hood flying open, striking and damaging windshield and blocking view of driver. Photos from incident scene and subsequent dealer inspection agree on fastener failure as the striker was found fully latched into the retainers. Fortunately…Owner complaint, filed 2026

The contact owns a 2024 Ford Expedition. The contact received notification of NHTSA Campaign Number: 26V368000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a…Owner complaint, filed 2026

What to check before you buy

• Turn the wheel lock to lock while parked and listen for groaning, clicking or binding.
• On a straight road the car should track straight with the wheel centered and no loose feeling.
• A power steering warning on the dash, even briefly, deserves a mechanic’s look before you buy.

Tools that help

What owners said

This was a rental vehicle obtained from Budget at [XXX]. On XXX at approximately 2:45 p.m., while driving south toward [XXX], the Ford Expedition developed increasingly severe rumbling and shaking and became difficult to control. All occupants noticed the condition. We reduced speed and pulled off at the first safe available location at…Owner complaint, filed 2026

The contact owns a 2024 Ford Expedition. The contact stated that while driving at various speeds, the message "Drive Assist Unavailable" was displayed. The contact stated that when the vehicle was turned off and restarted, the system was functional. The contact had taken the vehicle to a local dealer, who checked the 12-Volt battery and…Owner complaint, filed 2025, at 36,000 miles

What to check before you buy

• Pull out and latch every seat belt, and let each one retract on its own.
• Try every seat adjuster, and watch for a passenger air bag "off" light when an adult is in the seat.

Tools that help

What owners said

The contact rented a 2024 Ford Expedition from Enterprise Rent-A-Car. The contact stated that while the vehicle was parked and occupied, the contact was informed by his grandson that the seat belt was not operating properly. The contact inspected the seat belt and became aware that the third-row seat belt rear passenger’s side seat belt…Owner complaint, filed 2026, at 80,240 miles

I would like to report the seats. I bought my vehicle new. The seats has caused me to have medical issues. It has also caused one other person issues too, so it was not just me. I have never had any sort of back or leg issues before getting this vehicle. I now have severe Sciatica Nerve problems. Which, I have seen the Doctor for. It…Owner complaint, filed 2025

What to check before you buy

• Read the four-digit DOT date on each tire. Tires older than about six years should be replaced, whatever the tread looks like.
• Check tread depth on all four. On AWD vehicles all four tires should match.
• The tire pressure light should go out after startup.

Tools that help

What owners said

This was a rental vehicle obtained from Budget at [XXX]. On XXX at approximately 2:45 p.m., while driving south toward [XXX], the Ford Expedition developed increasingly severe rumbling and shaking and became difficult to control. All occupants noticed the condition. We reduced speed and pulled off at the first safe available location at…Owner complaint, filed 2026

Bought the car on Feb 14th 2026. We were told Avis car sales in fontana does their vehicle inspection on every car before its sold. We noticed the two back tires on the expedition were bald and showing cords. We told Tawnya and George about the tires and they said they would order them, they'd be in within two days and to bring the car…Owner complaint, filed 2026

What to check before you buy

• Drive over a few bumps and potholes slowly with the radio off and listen for clunks or rattles.
• Check the tires for uneven wear on the inside or outside edges, a sign of alignment or suspension trouble.
• Look behind the wheels for oily, wet shocks or struts.

Tools that help

What owners said

The differential came apart while my family and I were traveling on the highway out of town. This cause the vehicle to start violently jolting and wheels locked up. The vehicle began to skid across the center line into on coming traffic, we were almost hit head on and from behind due to this. My husband couldn’t get the vehicle to move…Owner complaint, filed 2025

The contact owns a 2024 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle was shaking and vibrating. The contact stated that the failure was present at various speeds. The vehicle was taken to the dealer several times regarding the failure, however the failure was not duplicated. The contact stated…Owner complaint, filed 2024, at 150 miles

What to check before you buy

• Smell around the engine bay and under the rear of the car for raw fuel.
• On the test drive, accelerate firmly from a stop and up a grade. Stumbling, surging or a flashing check engine light are red flags.
• Fuel pump recalls are common. Check this exact VIN for open recalls before you buy.

Tools that help

What owners said

The fuel line/fuel pump was leaking. Smelled fumes from the gasoline. Fuel was leaking over the fuel tank from the top of the tank. The vehicle was drivable when fuel was leaking. Very concerned that their could have been a fire due to the fuel leak. Took the vehicle to the Ford service department where it was purchased. Service shop…Owner complaint, filed 2025

Applied brakes and instead of braking, vehicle accelerated on its own. Please note, when brake applied, felt resistance and simultaneously vehicle accelerated into lane of traffic. Rate of speed was very low, as I was coming to a stop in a parking lot. No warning lights on dash, dealership confirmed it was not the floor mats, there are…Owner complaint, filed 2024

What to check before you buy

• The air bag (SRS) light should come on at startup and go out within a few seconds. If it stays on, the system may not work in a crash.
• Air bag recalls are some of the most serious. Check this exact VIN for open recalls and get proof any recall work was done.

Tools that help

What owners said

I actually have already sent in an assessment for airbag, but then read the recall on brakes, which at the time, because a new vehicle, I didn’t think possible. Even when pushing on my brakes, my vehicle was not slowing down like it should have, and I had a front end collision. It was hard for me to think this was because of brakes…Owner complaint, filed 2025

I was in a car accident on June 12, 2025, and my steering wheel airbag did not deploy correctly or function correctly. It was a front in straightforward collision. I did not have warning signs so my brakes could have been an issue because I was paying attention and unable to avoid an accident going under the speed limit. The rear cross…Owner complaint, filed 2025