2024 Ford Bronco Sport Problems

Half of the owners who gave a mileage had the problem by about 23,000 miles.

What to check before you buy

• Smell around the engine bay and under the rear of the car for raw fuel.
• On the test drive, accelerate firmly from a stop and up a grade. Stumbling, surging or a flashing check engine light are red flags.
• Fuel pump recalls are common. Check this exact VIN for open recalls before you buy.

Tools that help

What owners said

The contact owns a 2024 Ford Bronco Sport. The contact stated that the vehicle failed to start while parked. The contact stated that while driving, the vehicle decelerated and stalled. The check engine warning light was illuminated. The failure was a recurring failure. The contact waited 20 minutes before the vehicle operated as needed…Owner complaint, filed 2026, at 114,000 miles

The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that after the vehicle was turned off, there was an abnormal humming sound coming from under the hood, with an…Owner complaint, filed 2026, at 35,000 miles

What to check before you buy

• Ask the seller not to warm the car up, and start it cold. Listen for ticking, knocking or a rough idle in the first minute.
• Pull the oil dipstick and the oil cap. Low oil, a gasoline smell or a milky film on the cap are reasons to walk away or get an inspection.
• Plug in an OBD2 scanner. Stored or pending codes matter, and so do readiness monitors that show "not ready", which usually means the codes were cleared right before the sale.
• Ask for oil change records. A gap in the records on a model known for engine complaints is a negotiating point at minimum.

Tools that help

What owners said

2024 Bronco sport outer banks, exhaust fumes leaking the cabin when remote started or sitting idle at a stop. Also a loud rattle when the vehicle is running from the exhaust.Owner complaint, filed 2026

I own a 2024 Ford Bronco Sport equipped with the 1.5L EcoBoost 3-cylinder engine. On September 22, 2026, I remote-started the vehicle for approximately 10 minutes before leaving for work. The engine temperature reached its normal operating temperature, but the HVAC system produced no warm air even with the temperature set to 84°F/HI. I…Owner complaint, filed 2026

What to check before you buy

• Test every switch: windows, locks, mirrors, seat heaters, the screen, the backup camera, Bluetooth and every USB port.
• Watch the dash at startup. Every warning light should come on briefly and then go out.
• Have the battery and charging system tested. A weak alternator or battery drain shows up here.

Tools that help

What owners said

The contact owned a 2024 Ford Bronco Sport. The contact stated that while driving into the driveway and coming to a complete stop, the contact became aware of steam coming from underneath the hood and believed that the engine was overheating. No warning light was illuminated on the instrument panel prior to the vehicle catching on fire.…Owner complaint, filed 2026, at 15,000 miles

I am reporting ongoing electrical and infotainment system failures in my 2024 Ford Bronco Sport that present a potential safety risk to the driver and others on the road. The vehicle’s infotainment system, specifically Apple CarPlay and Android Auto, does not operate reliably. Connections frequently fail, freeze, disconnect, or become…Owner complaint, filed 2026

What to check before you buy

• Drive it from cold if you can. Shifts should be smooth in every gear, including reverse.
• Feel for slipping (revs rise without the car speeding up), shudder at low speed and a delay when you put it in gear.
• Listen for whining, which is a common CVT complaint, and clunks when you go from drive to reverse.
• If it has 4WD or AWD, engage it on the test drive and ask when the transmission and differential fluids were last changed.

Tools that help

What owners said

On Sunday XXX I left my property at [XXX] and at the first stop sign, I braked but the vehicle accelerated causing me to jam the breaks and the engine immediately died. After restarting, and in drive at the stop sign, the vehicle accelerated on its own with my foot on the break, I jammed the breaks and the engine again quit. In this…Owner complaint, filed 2026

I am experiencing severe drivetrain binding and violent shuddering/chatter from the Rear Drive Unit (RDU) during low-speed turns in both directions. The vehicle hesitates and can stop violently on its own while turning. When the vehicle is parked and shut off, it also violently jerks backward, indicating the RDU is binding and storing…Owner complaint, filed 2026

What to check before you buy

• The pedal should feel firm and the car should stop straight without pulling, grinding or a pulsing pedal.
• The ABS and stability control lights should go out after startup and stay out.
• Look through the wheels at the rotors. A deep lip on the edge means brakes are due soon, which is a fair thing to negotiate on.

Tools that help

What owners said

The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed and making a right turn, there was an abnormal sound coming from the rear of the vehicle. The vehicle remained at the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure…Owner complaint, filed 2026, at 200 miles

• What component or system failed or malfunctioned, and is it available for inspection? The brake system on my 2024 Ford Bronco Sport failed to respond for approximately 2, 3 seconds after I pressed the brake pedal. This occurred immediately after freeing my foot from underneath the gas pedal while cruise control was active. The vehicle…Owner complaint, filed 2025

What to check before you buy

• Look underneath with a flashlight. Utah road salt is hard on frames, brake lines and the bottoms of doors.
• Open and close every door, the hood and the liftgate, and lock and unlock each one.
• Use a paint thickness gauge and compare panels. A panel that reads very differently from the rest has likely been repaired.

Tools that help

What owners said

The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the hood independently unlatched and flew open. The front windshield was cracked, and other damage to the vehicle was sustained. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that…Owner complaint, filed 2026, at 31,000 miles

The contact rented a 2024 Ford Bronco Sport. The contact stated that while driving approximately 30-35 MPH, the hood flew open, struck and cracked the windshield, completely obstructing the driver's visibility. The contact pulled over to the curb and then into a parking lot. The contact stated that he was disabled, and that the failure…Owner complaint, filed 2026

What to check before you buy

• Where it is safe, try the adaptive cruise and lane keeping on the test drive and watch for sudden braking or warnings with nothing there.
• Check the windshield in front of the camera and the bumper sensors for cracks, chips or poor repairs.
• Ask whether the windshield has been replaced. The camera has to be recalibrated afterward, and many shops skip it.

Tools that help

What owners said

The entire Advanced Drive Assistants Systems only works when it feels like it. Thankfully I haven't had any accidents yet..., but I have come very close to it three times. Especially when the lane system went down, it almost sent me into the car next to me.Owner complaint, filed 2025

Front seats Cause back and hip pain and fatigue on trips over 30 mins- head rest don’t adjust to help compensate putting in awkward positioning. The automatic braking or whatever signifies your close to objects in the front has randomly breaked hard with nothing near me almost resulting in being rear rear ended.Owner complaint, filed 2026

What to check before you buy

• Check every light: headlights on low and high, fog lights, brake lights, turn signals and reverse lights.
• Run the wipers on every speed with washer fluid, and run the defroster front and back.

Tools that help

What owners said

The contact owns a 2024 Ford Bronco Sport. The contact stated that while the vehicle was parked outside, the front windshield cracked. The front windshield had a long horizontal crack. There was no warning light illuminated. Upon inspection, the crack had started from the inside of the windshield. The vehicle was taken to the dealer…Owner complaint, filed 2025, at 3,500 miles

The windshield on this vehicle is faulty. On online forms, others have commented on the same thing I am experiencing: the integrity of this windshield is so weak that within a couple months (sometimes just a few days) of having the vehicle, you can get multiple chips or cracks. On my last chip, I was driving on a Michigan highway at…Owner complaint, filed 2025

What to check before you buy

• Read the four-digit DOT date on each tire. Tires older than about six years should be replaced, whatever the tread looks like.
• Check tread depth on all four. On AWD vehicles all four tires should match.
• The tire pressure light should go out after startup.

Tools that help

What owners said

225/65 R 17 A small sliver of wood Punctured the sidewall which is unbelievable that a tire would be that weak from what appears to be a blunt puncture on a Ford Bronco Sport made for all kinds of off and on road driving conditions and something as small as a flattened tooth pick would be sufficient as a safe tire. Looking at continental…Owner complaint, filed 2026

The contact owns a 2024 Ford Bronco Sport equipped with Continental Tires, Tire Line: Cross Contact, Tire Size: 225/65R/17, and DOT Number: [XXX] . The contact stated that while driving at approximately 70 MPH, the contact heard an abnormally loud sound coming from the rear end of the vehicle, and the contact noticed that the rear…Owner complaint, filed 2025, at 8,000 miles

What to check before you buy

• Turn the wheel lock to lock while parked and listen for groaning, clicking or binding.
• On a straight road the car should track straight with the wheel centered and no loose feeling.
• A power steering warning on the dash, even briefly, deserves a mechanic’s look before you buy.

Tools that help

What owners said

Clonninger Auto Body Shop 511 Jake Alexander Blvd S Salisbury NC 28147 The 2024 Bronco Sport owned by Megan Michaels was presented to our service department with a customer concern of a rattling noise coming from the rear of the vehicle, along with abnormal tire wear on the rear tires. Our Master Technician performed a road test and…Owner complaint, filed 2026

Chattering/screeching from right side of the car. Near tires. Took it in and showed example to technician and he heard it. Comes when turning right or backing up right slowly. They discovered it was the rear differential unit and it will be in the shop for 1-2 weeks.Owner complaint, filed 2025

What to check before you buy

• On the test drive, press the gas gently and firmly. The response should be smooth with no lag or surge.
• Set the cruise control, then use resume and cancel to make sure each one works.

Tools that help

What owners said

I don’t know the exact name of the system that failed but my Bronco would not accelerate after making complete stops. When I would press on the gas pedals to move from a stopped position the Bronco would move very very slowly which in turn almost caused me to have over 3 car accidents as when I would press the gas to move from a stopping…Owner complaint, filed 2025

The Powertrain of this Ford Bronco Sport (2024) with only 12,000 miles on it malfunctioned while the driver was on a major highway. No control over gears, engine power, etc. Had to pull over in heavy traffic. Fortunately there was a shoulder, or this would have been a major safety risk for the driver and other vehicles and would likely…Owner complaint, filed 2025

What to check before you buy

• Drive over a few bumps and potholes slowly with the radio off and listen for clunks or rattles.
• Check the tires for uneven wear on the inside or outside edges, a sign of alignment or suspension trouble.
• Look behind the wheels for oily, wet shocks or struts.

Tools that help

What owners said

Clonninger Auto Body Shop 511 Jake Alexander Blvd S Salisbury NC 28147 The 2024 Bronco Sport owned by Megan Michaels was presented to our service department with a customer concern of a rattling noise coming from the rear of the vehicle, along with abnormal tire wear on the rear tires. Our Master Technician performed a road test and…Owner complaint, filed 2026

Chattering/screeching from right side of the car. Near tires. Took it in and showed example to technician and he heard it. Comes when turning right or backing up right slowly. They discovered it was the rear differential unit and it will be in the shop for 1-2 weeks.Owner complaint, filed 2025

What to check before you buy

• Pull out and latch every seat belt, and let each one retract on its own.
• Try every seat adjuster, and watch for a passenger air bag "off" light when an adult is in the seat.

Tools that help

What owners said

Front seats Cause back and hip pain and fatigue on trips over 30 mins- head rest don’t adjust to help compensate putting in awkward positioning. The automatic braking or whatever signifies your close to objects in the front has randomly breaked hard with nothing near me almost resulting in being rear rear ended.Owner complaint, filed 2026

Passenger seatbelt doesn’t loosen up driven normal. Adaptive cruise control doesn’t work, never has. I didn’t know about it until Monday I am taking it to a ford dealership today at Ken Garff Ford. .Owner complaint, filed 2026