2022 Ford Bronco Sport Problems

Half of the owners who gave a mileage had the problem by about 44,000 miles.

What to check before you buy

• Smell around the engine bay and under the rear of the car for raw fuel.
• On the test drive, accelerate firmly from a stop and up a grade. Stumbling, surging or a flashing check engine light are red flags.
• Fuel pump recalls are common. Check this exact VIN for open recalls before you buy.

Tools that help

What owners said

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to complete the recall repair was not available. The local dealer was contacted several times and confirmed that the parts were unavailable. The contact stated the manufacturer…Owner complaint, filed 2026

Formal Complaint: Unresolved Safety Hazard and Delayed Remedy (NHTSA Campaign 25V-467 / Ford Recall 25S76) ​I am writing to express severe concern regarding Ford Motor Company's ongoing failure to provide a permanent, physical fix for the cracked fuel injector fire hazard in my vehicle. Since the initial recall action in late 2022…Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 46,000 miles.

What to check before you buy

• Ask the seller not to warm the car up, and start it cold. Listen for ticking, knocking or a rough idle in the first minute.
• Pull the oil dipstick and the oil cap. Low oil, a gasoline smell or a milky film on the cap are reasons to walk away or get an inspection.
• Plug in an OBD2 scanner. Stored or pending codes matter, and so do readiness monitors that show "not ready", which usually means the codes were cleared right before the sale.
• Ask for oil change records. A gap in the records on a model known for engine complaints is a negotiating point at minimum.

Tools that help

What owners said

Vehicle developed a hum when accelerating on July 5, 2026. Made an appointment with the dealership to have it diagnosed. They could not get me in until July 16, 2026. On July 15, 2026, the vehicle went into limp mode and had to be driven at an unsafe speed to the dealership to diagnose and repair the issue. There are 81,000 miles on the…Owner complaint, filed 2026

I have replaced the water pump THREE times on this Bronco Sport. It has been every 18 months or about every 20,000 miles. I made the report in March of 2025, never heard anything. Making another report now as it is currently in the shop getting the water pump replaced for the THIRD TIME!!!Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 35,000 miles.

What to check before you buy

• Test every switch: windows, locks, mirrors, seat heaters, the screen, the backup camera, Bluetooth and every USB port.
• Watch the dash at startup. Every warning light should come on briefly and then go out.
• Have the battery and charging system tested. A weak alternator or battery drain shows up here.

Tools that help

What owners said

Rats are attracted to the soy based wire coating. They ate every coating off every wire in the entire car, which cost a fortune to fix! I want a new car without that wire coating. I shouldn't be responsible for this mess! It's a known problem. My car is spotless! No food or drinks allowed. The guy who fixed it said he had never seen…Owner complaint, filed 2026

The contact owns a 2022 Ford Bronco Sport. The contact stated that while operating the vehicle, several unknown warning lights flashed on the instrument panel and then disappeared. Additionally, there was a soft, audible chime coming from the rear of the vehicle, and the Wi-Fi and Bluetooth systems activated the connections despite no…Owner complaint, filed 2026, at 40,000 miles

Half of the owners who gave a mileage had the problem by about 38,000 miles.

What to check before you buy

• Drive it from cold if you can. Shifts should be smooth in every gear, including reverse.
• Feel for slipping (revs rise without the car speeding up), shudder at low speed and a delay when you put it in gear.
• Listen for whining, which is a common CVT complaint, and clunks when you go from drive to reverse.
• If it has 4WD or AWD, engage it on the test drive and ask when the transmission and differential fluids were last changed.

Tools that help

What owners said

The rear drive unit (RDU) deteriorated at 78k miles. I began to notice a shudder during low-speed turns with high steering angle. Upon inspection, metallic flakes were discovered in the RDU’s fluid, apparently indicating mechanical degradation of the internal clutch packs. Two separate Ford dealerships recommended complete RDU assembly…Owner complaint, filed 2026

I have a 2022 Ford Bronco Sport Outer Banks that I bought brand new. I special ordered it and had it delivered to a dealership in Jacksonville IL. The vehicle has 107,000 miles on it. On XXX while driving to work my car completely quite running in the middle of a busy intersection with cars speeding by us and me and my fiance were both…Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 13,000 miles.

What to check before you buy

• The pedal should feel firm and the car should stop straight without pulling, grinding or a pulsing pedal.
• The ABS and stability control lights should go out after startup and stay out.
• Look through the wheels at the rotors. A deep lip on the edge means brakes are due soon, which is a fair thing to negotiate on.

Tools that help

What owners said

While driving, an severe and persistent rear brake resonance defect occurs during braking operations. The defect manifests as high-frequency vibration, loud grinding, and low-speed brake shudder/chatter from the rear braking system, impacting vehicle control and braking predictability under normal driving conditions. The affected…Owner complaint, filed 2026

Brake components showing signs of failure at 28,000 miles on both front and rear brakes. Safety placed at risk given speed and general use of vehicle which includes passengers. This includes grinding stops, increasing foot pressure used to stop car, and under certain conditions reconsidering use of vehicle. Ford dealership inspected…Owner complaint, filed 2026

Parts named most: Warnings (8), Adaptive cruise control (7).

What to check before you buy

• Where it is safe, try the adaptive cruise and lane keeping on the test drive and watch for sudden braking or warnings with nothing there.
• Check the windshield in front of the camera and the bumper sensors for cracks, chips or poor repairs.
• Ask whether the windshield has been replaced. The camera has to be recalibrated afterward, and many shops skip it.

Tools that help

What owners said

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE). The contact stated that while driving around the neighborhood at slow speeds, the "Forward Collision Warning" system failed to function as intended. The contact stated that the alarm sounded while…Owner complaint, filed 2026, at 40,000 miles

At approximately 7:00 p.m., it was already dark, and I relied on my vehicle’s rear parking-aid sensor to assist me while backing out of my driveway. However, the rear collision/parking-aid sensor did not activate and provided no audible or visual warnings. Because the sensor failed to operate, I continued reversing and unintentionally…Owner complaint, filed 2025

What to check before you buy

• Check every light: headlights on low and high, fog lights, brake lights, turn signals and reverse lights.
• Run the wipers on every speed with washer fluid, and run the defroster front and back.

Tools that help

What owners said

The contact owns a 2022 Ford Bronco Sport. The contact stated while his son was parked in the driveway, the rear passenger’s side window failed to roll up as intended. The vehicle was taken to an independent mechanic where it was diagnosed that the rear passenger’s side window motor was inoperable. The vehicle was not repaired. The…Owner complaint, filed 2024, at 37,000 miles

There are at least three separate chips on windshield caused by very small gravel on different occasions. The windshield should not be chipping so easily. The most recent happened yesterday and immediately spread. The cost of these windshields are pricey due to rain sensors. integrity of windshield seems compromised for whatever…Owner complaint, filed 2024

What to check before you buy

• Turn the wheel lock to lock while parked and listen for groaning, clicking or binding.
• On a straight road the car should track straight with the wheel centered and no loose feeling.
• A power steering warning on the dash, even briefly, deserves a mechanic’s look before you buy.

Tools that help

What owners said

The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the contact turned on the heated steering wheel feature, and 30 seconds later, the steering wheel cover began to catch on fire with a blue flame; the contact discovered smoke coming from the steering wheel cover. The contact…Owner complaint, filed 2026, at 80,000 miles

The contact's wife owns a 2022 Ford Bronco Sport. The contact stated while his wife was driving and making a left or a right turn, the steering wheel locked inadvertently. The contact stated that while forcefully turning the steering wheel, the steering wheel made an abnormally loud grinding sound. The check engine warning light was…Owner complaint, filed 2024, at 9,000 miles

What to check before you buy

• On the test drive, press the gas gently and firmly. The response should be smooth with no lag or surge.
• Set the cruise control, then use resume and cancel to make sure each one works.

Tools that help

What owners said

The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving 60 MPH with the cruise control engaged, while slowing down to exit the freeway, the cruise control failed to disengage, and the vehicle continued driving at 60 MPH. There was no warning light illuminated. The contact depressed the brake pedal several times…Owner complaint, filed 2025, at 33,000 miles

The contact owns a 2022 Ford Bronco. The contact stated that while his daughter was attempting to park, the vehicle suddenly accelerated forward and crashed into the door of a building. While reversing from the building, the vehicle accelerated. The driver sustained injuries to her foot and was sent to the hospital where medical…Owner complaint, filed 2023, at 5,000 miles

What to check before you buy

• The air bag (SRS) light should come on at startup and go out within a few seconds. If it stays on, the system may not work in a crash.
• Air bag recalls are some of the most serious. Check this exact VIN for open recalls and get proof any recall work was done.

Tools that help

What owners said

I was driving to work in my 2022 Ford Bronco Sport when traffic ahead of me stopped suddenly. I was able to come to a complete stop. The vehicle behind me did not see the stopped traffic until the last second and rear-ended my vehicle at an estimated speed of approximately 50 mph. The impact was severe enough that my vehicle was pushed…Owner complaint, filed 2026

Air bags failed to deploy when the car hit a tree. Issue has not be reproduced or confirmed by a dealer or independent service center. Vehicle has been inspected by claims adjuster only. There were no messages or symptoms of an issue prior to failure.Owner complaint, filed 2024

What to check before you buy

• Pull out and latch every seat belt, and let each one retract on its own.
• Try every seat adjuster, and watch for a passenger air bag "off" light when an adult is in the seat.

Tools that help

What owners said

I was driving the car and had been noticing an aroma, that I couldn't identify all morning. I happened to look over to the passenger side of the car and smoke was coming from the front of the seat. It was just about to catch fire. The seat heater was on and I turned it off. I poured water from a water bottle on the burned spot, that is…Owner complaint, filed 2026

They sent me 2 papers about recalls and refused to fix it. Whatsoever, they tell me the fuel injection has to go out so they would fix it before even though they know it's bad. The second is a seat belt that click sometimes so basically they won't fix that either until it breaks completely. So what they're saying is basically the car can…Owner complaint, filed 2025

What to check before you buy

• Drive over a few bumps and potholes slowly with the radio off and listen for clunks or rattles.
• Check the tires for uneven wear on the inside or outside edges, a sign of alignment or suspension trouble.
• Look behind the wheels for oily, wet shocks or struts.

Tools that help

What owners said

Front and rear axle, 4 wheel drive, and differential issues, causing steering, wheel, and driving issues. There is a nationwide back order on parts needed to repair this common, and known issue, leaving Ford service to return customers to continue driving unsafe vehicles until parts arrive. Despite Ford having knowledge of this safety…Owner complaint, filed 2026

When turning any direction or hitting speeds of 75 mph +, vehicle makes loud noise and starts shaking. Took it to an independent mechanic and ran a diagnostic, they said the rear differential is going out which isn't normal for vehicles with this mileage and said it was a manufacturer defect. When I took the vehicle to a Ford dealership…Owner complaint, filed 2026

Parts named most: Body (7).

What to check before you buy

• Look underneath with a flashlight. Utah road salt is hard on frames, brake lines and the bottoms of doors.
• Open and close every door, the hood and the liftgate, and lock and unlock each one.
• Use a paint thickness gauge and compare panels. A panel that reads very differently from the rest has likely been repaired.

Tools that help

What owners said

The firewall on the passenger side was not sealed correctly causing water to enter behind the glove box affecting the blower motor and causing water to enter the vehicle. Causing mold under the carpet. The leak was confirmed at the Ford dealershipOwner complaint, filed 2025

The hood latch and cabling mechanism continues to be a problem for Bronco Sport owners. I have dealt with the cabling detaching from the housing unit four times. This causes safety concerns because the hood cannot be opened when this issue presents. Many owners have this issue.Owner complaint, filed 2025

What to check before you buy

• Read the four-digit DOT date on each tire. Tires older than about six years should be replaced, whatever the tread looks like.
• Check tread depth on all four. On AWD vehicles all four tires should match.
• The tire pressure light should go out after startup.

Tools that help

What owners said

All tires are completely worn at 37,000 miles causing my braking stop time to increase and traction reduction when roads are wet and slippery. Also the tires are now making a rubbing sound when turning and was told it may be due to the way the tire tread has worn. Continental 225 / 65 R17Owner complaint, filed 2024