2020 Hyundai Sonata Problems

Half of the owners who gave a mileage had the problem by about 78,000 miles.

What to check before you buy

• Smell around the engine bay and under the rear of the car for raw fuel.
• On the test drive, accelerate firmly from a stop and up a grade. Stumbling, surging or a flashing check engine light are red flags.
• Fuel pump recalls are common. Check this exact VIN for open recalls before you buy.

Tools that help

What owners said

The car has strong fuel smell in the cabin when tank is full, It is especially strong after car sits. I have taken to hyundai several times for this problem. They say the computer says nothing is wrong. They refuse to investigate as they dont smell the odor.Owner complaint, filed 2026

Hyundai Motors America has failed to comply with its statutory obligations in conducting the recall campaign 25V796, and is instead engaging in behavior substantially similar to that which has been previously censured by NHTSA. My Sonata suffered irreparable damage related to this campaign as confirmed by HMA. 49 U.S.C. § 30120(a)(1)(A)…Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 10,000 miles.

What to check before you buy

• Test every switch: windows, locks, mirrors, seat heaters, the screen, the backup camera, Bluetooth and every USB port.
• Watch the dash at startup. Every warning light should come on briefly and then go out.
• Have the battery and charging system tested. A weak alternator or battery drain shows up here.

Tools that help

What owners said

A/C blower motor fan would stop working. Happened twice within less than a year apart. Upon further inspection, multi fuse wiring overheated and melted, ruining fuse and making A/C stop working during 100+ temperatures outside. Apparently this is a well known issue with this make and model Sonata. Electrical failure.Owner complaint, filed 2026

The AC/heating blower motor circuit on my 2020 Hyundai Sonata failed intermittently due to extreme electrical resistance overheating and melting the terminal pins inside the engine fuse box. I took it to the dealership and they inspected it said it was out of warranty but it needed part number 18980-09910-FFF and wiring kit 91300L1000-FF…Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 31,000 miles.

What to check before you buy

• Ask the seller not to warm the car up, and start it cold. Listen for ticking, knocking or a rough idle in the first minute.
• Pull the oil dipstick and the oil cap. Low oil, a gasoline smell or a milky film on the cap are reasons to walk away or get an inspection.
• Plug in an OBD2 scanner. Stored or pending codes matter, and so do readiness monitors that show "not ready", which usually means the codes were cleared right before the sale.
• Ask for oil change records. A gap in the records on a model known for engine complaints is a negotiating point at minimum.

Tools that help

What owners said

The A/C evaporator core and the core seal needs replacing on 2020 Hyundai Sonata. Car is 6 years old. I already have a confirmed diagnosis with a PPM refrigerant leak tester at the condensate drain line The diagnosis is 100% confirmed. The evaporator is leaking heavily, we pulled 274 PPM at the drain tube and 177 PPM inside the cabin…Owner complaint, filed 2026

The contact owns a 2020 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated. The contact added oil to the engine. The dealer was made aware of the failure. The vehicle was taken to the dealer several times, and several oil consumption tests were performed. The contact was…Owner complaint, filed 2026, at 80,000 miles

Half of the owners who gave a mileage had the problem by about 17,000 miles.

What to check before you buy

• Drive it from cold if you can. Shifts should be smooth in every gear, including reverse.
• Feel for slipping (revs rise without the car speeding up), shudder at low speed and a delay when you put it in gear.
• Listen for whining, which is a common CVT complaint, and clunks when you go from drive to reverse.
• If it has 4WD or AWD, engage it on the test drive and ask when the transmission and differential fluids were last changed.

Tools that help

What owners said

My certified pre-owned 2020 Hyundai Sonata has experienced the same critical transmission failure three times since October 2024, creating dangerous safety conditions on highways and city streets. Component/System Failed: Transmission control system with consistent P0768 error code (Shift Solenoid D Circuit Fault). Safety Risks: The…Owner complaint, filed 2025

The contact owns a 2020 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the shift assists malfunction warning light illuminated. The contact turned the vehicle off and restarted the vehicle. The vehicle was towed to the dealer; however, the failure could not be duplicated. The vehicle was not repaired. The…Owner complaint, filed 2024, at 21,000 miles

Half of the owners who gave a mileage had the problem by about 9,000 miles. Parts named most: Warnings (10).

What to check before you buy

• Where it is safe, try the adaptive cruise and lane keeping on the test drive and watch for sudden braking or warnings with nothing there.
• Check the windshield in front of the camera and the bumper sensors for cracks, chips or poor repairs.
• Ask whether the windshield has been replaced. The camera has to be recalibrated afterward, and many shops skip it.

Tools that help

What owners said

The reverse camera only shows a black screen and will put drivers in danger while not being able to see behind them while reversing. This needs to be recalled and repaired. Especially in situations where a person is reversing out of a driveway onto a major/busy road. Sometimes it works, but a lot of the time it is just a black screen…Owner complaint, filed 2026

The contact owns a 2020 Hyundai Sonata. The contact stated while driving at various speeds, the vehicle experienced phantom braking and nearly came to a complete stop. The contact stated that the automatic emergency braking system unexpectedly engaged while there were no roadway obstacles or vehicles near the vehicle. The vehicle was…Owner complaint, filed 2026, at 2,000 miles

What to check before you buy

• Pull out and latch every seat belt, and let each one retract on its own.
• Try every seat adjuster, and watch for a passenger air bag "off" light when an adult is in the seat.

Tools that help

What owners said

The driver's power seat track master assembly (Part#88500-L0030) on my 2020 Hyundai Sonata suffered a catastrophic structural failure while operating. The black plastic bracket housing and aligning the electric drive motor fractured. This caused the motor to pull out of alignment, twisting the driver's seat violently sideways and…Owner complaint, filed 2026

The seat belt latches do not latch or will spontaneously unlatch. This has been a problem for about 4 years. I have checked for recalls and not seen any for my car. I will check with the dealer but have tried vacuuming the latches without effect. I have never experienced anything like this in any previous vehicle. The warning buzzer lets…Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 1,000 miles. Parts named most: Body (13).

What to check before you buy

• Look underneath with a flashlight. Utah road salt is hard on frames, brake lines and the bottoms of doors.
• Open and close every door, the hood and the liftgate, and lock and unlock each one.
• Use a paint thickness gauge and compare panels. A panel that reads very differently from the rest has likely been repaired.

Tools that help

What owners said

Upon arriving home I noticed that the paint was missing from the back passenger side & when I left the parking lot before heading home there was no paint missing.Owner complaint, filed 2026

I own a 2020 Hyundai Sonata with factory-applied paint. The vehicle developed paint peeling/clear-coat failure on the driver-side rear quarter panel without any prior damage, accident, or repainting. The paint began separating from the body, exposing the underlying surface. I brought the vehicle to an authorized Hyundai dealer. The…Owner complaint, filed 2025

What to check before you buy

• Check every light: headlights on low and high, fog lights, brake lights, turn signals and reverse lights.
• Run the wipers on every speed with washer fluid, and run the defroster front and back.

Tools that help

What owners said

My vehicle is missing it's third brake light. We have confirmed that it was forgotten during manufacturing. The dealer won't cover it. They say call corporate. Corporate says dealer has to fix it. In the mean time I'm pulled over for improper equipment, and brake light being out. It's a serious safety issue, covered by federal law. They…Owner complaint, filed 2024

The Panoramic sunroof has a line fracture crack which exploded for unknown reasons. A rock or any foreign object DID NOT hit the sunroof to cause it to shatter. Residue from the glass shattering got into my eyes. Freeman Hyundai stated that an object hit the sunroof it would not be covered under their warranty. A object did not hit the…Owner complaint, filed 2022

What to check before you buy

• Turn the wheel lock to lock while parked and listen for groaning, clicking or binding.
• On a straight road the car should track straight with the wheel centered and no loose feeling.
• A power steering warning on the dash, even briefly, deserves a mechanic’s look before you buy.

Tools that help

What owners said

2020 Sonata......Steering wheel has started to make a raspy, rubbing noise when turned. When researching this problem on U tube, it is apparently a fairly common problem with Hyundai vehicles. The fix requires that a bearing in the steering be replaced. If not replaced I would imagine that the bearing would eventually seize up and the…Owner complaint, filed 2022

Steering wheel makes whining/scrubbing noise when turning. Steering a vehicle is a critical component of safety and being able to avoid dangerous situations. The problem has been reported, inspected, and confirmed by a dealer. The component has not been inspected by the manufacturer, police, or independent service center. There were no…Owner complaint, filed 2021

What to check before you buy

• On the test drive, press the gas gently and firmly. The response should be smooth with no lag or surge.
• Set the cruise control, then use resume and cancel to make sure each one works.

Tools that help

What owners said

On or about November 13, 2024 our Hyundai Sonata 2020 gas tank almost exploded. We drove our vehicle to a dealership so that it could be checked because we kept hearing something that sounded like a loud pop / thumb underneath our vehicle. We had already been receiving notifications of a powertrain issue with the vehicle for years…Owner complaint, filed 2025

while driving my car on 3 different days the car slowed down, and the lights came EPB on, on the dashboard the EPB light came on the check engine light came on , forward collision light, auto hold light, slippery road light , and caution light with a ! mark.Owner complaint, filed 2024

Half of the owners who gave a mileage had the problem by about 2,000 miles.

What to check before you buy

• The air bag (SRS) light should come on at startup and go out within a few seconds. If it stays on, the system may not work in a crash.
• Air bag recalls are some of the most serious. Check this exact VIN for open recalls and get proof any recall work was done.

Tools that help

What owners said

I never got what I wanted from hyundai. I was told that you cannot use a cushion and have a passenger airbag.. I went up to ceo, still same answer. I tried.Owner complaint, filed 2020, at 1,768 miles

This is still a problem which is unsolved. I was told to go to a body to raise the seat. The body shop refused saying it would shift responsibility to them instead of hyundai.not having much luck as of yet.Owner complaint, filed 2020, at 1,790 miles

What to check before you buy

• The pedal should feel firm and the car should stop straight without pulling, grinding or a pulsing pedal.
• The ABS and stability control lights should go out after startup and stay out.
• Look through the wheels at the rotors. A deep lip on the edge means brakes are due soon, which is a fair thing to negotiate on.

Tools that help

What owners said

The contact owns a 2020 Hyundai Sonata. The contact stated that while depressing the brake pedal, the front of the vehicle was wobbling. The vehicle was taken to a dealer where it was diagnosed that the rotors needed to be resurfaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure…Owner complaint, filed 2021, at 11,000 miles

Vehicle experienced intermittent, severe powertrain defect resulting in a critical safety hazard. Between 30K and 36K miles, the vehicle underwent 3 violent highway deceleration episodes. During these events, the engine began shaking, escalating to violent shaking; with deceleration and coming to a stop, it would shake, then sputter as…Owner complaint, filed 2026

What to check before you buy

• Read the four-digit DOT date on each tire. Tires older than about six years should be replaced, whatever the tread looks like.
• Check tread depth on all four. On AWD vehicles all four tires should match.
• The tire pressure light should go out after startup.

Tools that help

What owners said

On august 14th,2020, I purchased a vehicle from the showroom floor from crain hyundai of conway, arkansas. The car was aesthetically pleasing and only had 46 miles on the speedometer. At the time of the purchase I was not aware of the term "modification" nor the ramification associated with having a vehicle modified. I assumed the…Owner complaint, filed 2020, at 2,855 miles

So I was driving down the highway and I went to pass a car, (I never get close when passing) I was probably at least a quarter mile away from the car I was passing. I have every safety feature turned off, as I have, since buying the car almost 2 years ago. All of a sudden, I’m not sure if my sensor was off or what, but I’m assuming it…Owner complaint, filed 2025