2016 Kia Sorento Problems

Half of the owners who gave a mileage had the problem by about 84,000 miles.

What to check before you buy

• Ask the seller not to warm the car up, and start it cold. Listen for ticking, knocking or a rough idle in the first minute.
• Pull the oil dipstick and the oil cap. Low oil, a gasoline smell or a milky film on the cap are reasons to walk away or get an inspection.
• Plug in an OBD2 scanner. Stored or pending codes matter, and so do readiness monitors that show "not ready", which usually means the codes were cleared right before the sale.
• Ask for oil change records. A gap in the records on a model known for engine complaints is a negotiating point at minimum.

Tools that help

What owners said

The contact owns a 2016 Kia Sorento. The contact stated that there was coolant intrusion into the engine. The failure was associated with Technical Service Bulletin: 253 (Rev 1, WTY035 - Warranty Extension Program). The contact stated that the issue was caused by a failure of the iron screws on the engine. The dealer was contacted and…Owner complaint, filed 2026, at 148,764 miles

I am the original owner of a 2016 Kia Sorento and have lived at my original registration address since purchasing the vehicle. The engine suddenly and catastrophically failed/seized due to internal rod bearing failure. The local Kia dealership is denying the recall engine replacement because the KSDS (Knock Sensor Detection System)…Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 71,000 miles.

What to check before you buy

• Drive it from cold if you can. Shifts should be smooth in every gear, including reverse.
• Feel for slipping (revs rise without the car speeding up), shudder at low speed and a delay when you put it in gear.
• Listen for whining, which is a common CVT complaint, and clunks when you go from drive to reverse.
• If it has 4WD or AWD, engage it on the test drive and ask when the transmission and differential fluids were last changed.

Tools that help

What owners said

I have a 2016 kia sorento I was having a problem with the shifter it would not go into park and had to use the shift override button I contacted the dealer there was an active recall they refused to repair or replace the shifter because it was inspected by the dealer in 2022 and as far as they where concerned that satisfied the recall…Owner complaint, filed 2026

2016 Kia Sorento 2.4 mileage 75,500 (just out of warranty as of Jan 2026), vehicle is having transmission issue, hard shifting/jerking from1st gear to 2nd gear on first cold start-up of the day. No warning lamps on. Took into Kia to have the transmission serviced, cost $462, did not solve the issues. Kia paperwork upon completion of…Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 50,000 miles. Parts named most: Body (106).

What to check before you buy

• Look underneath with a flashlight. Utah road salt is hard on frames, brake lines and the bottoms of doors.
• Open and close every door, the hood and the liftgate, and lock and unlock each one.
• Use a paint thickness gauge and compare panels. A panel that reads very differently from the rest has likely been repaired.

Tools that help

What owners said

I am the original, single owner of a 2016 Kia Sorento in Snow White Pearl. My vehicle currently has approximately 96,000 miles on it. Roughly one year ago, the factory paint began catastrophically peeling, flaking, and deteriorating in large sheets on the roof and near the passenger-side door. This damage is not the result of…Owner complaint, filed 2026

Vehicle: 2016 Kia Sorento EX VIN: [XXX] Current Mileage: Approximately 67,000 Component: Paint/Body (Exterior Finish) My 2016 Kia Sorento (Snow White Pearl / Pearl White) has developed premature, multi-panel paint failure. Flaking began appearing on the roof rail area above the front doors in late summer 2025, followed by flaking on the…Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 52,000 miles.

What to check before you buy

• Test every switch: windows, locks, mirrors, seat heaters, the screen, the backup camera, Bluetooth and every USB port.
• Watch the dash at startup. Every warning light should come on briefly and then go out.
• Have the battery and charging system tested. A weak alternator or battery drain shows up here.

Tools that help

What owners said

My headlights flicker when the left turn signal is used. I have taken this vehicle to the dealership previously for headlight flickering issues. I have owned it since 2019. When the lights flicker at night driving at highway speeds, it is dangerous for me and other drivers around me. The Ray Skillman Kia dealer has confirmed these issues…Owner complaint, filed 2025

Odometer Fraud. The contact purchased a 2016 Kia Sorento. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 97,000, and at the time of registration, it was discovered that the mileage…Owner complaint, filed 2025

Half of the owners who gave a mileage had the problem by about 40,000 miles.

What to check before you buy

• Check every light: headlights on low and high, fog lights, brake lights, turn signals and reverse lights.
• Run the wipers on every speed with washer fluid, and run the defroster front and back.

Tools that help

What owners said

I have now replaced the headlight bulbs in my 2016 KIA Sorento 6 times and it's getting worse as it gets older. I believe it is a safety issue since the last time I was out of town, traveling in the middle of the night when it went out. I had to wait until morning to find an auto parts store to buy and replace the bulb. No inspections…Owner complaint, filed 2025

Driver side headlight keeps going out. Bulb doesn’t blow and fuses are fine….take the bulb out and put back in and after a couple minutes light starts working again for a couple days before it goes back out. If you go to the passenger side and pull that one out the bulb is smoking.Owner complaint, filed 2025

Half of the owners who gave a mileage had the problem by about 48,000 miles.

What to check before you buy

• Turn the wheel lock to lock while parked and listen for groaning, clicking or binding.
• On a straight road the car should track straight with the wheel centered and no loose feeling.
• A power steering warning on the dash, even briefly, deserves a mechanic’s look before you buy.

Tools that help

What owners said

The Steering binds/ sticks at the 12 o’clock position on the highway, requiring sudden extra physical force to break free, which causes the vehicle to oversteer left to right. For record, Auffenberg Kia verified a steering torque measurement of 7.3 Nm (failure limit: 4.5 Nm) per TSB CHA060, but denied warranty repair under WTY023 solely…Owner complaint, filed 2026

3 to 4 months ago my truck steering wheel light with an exclamation point will appear and my steering wheel will lock up and it is hard to steer unless I cut the truck off and back on, it is so dangerous that it went out when I was in the middle of a turn that I almost ran into a truck. I cannot get this issue fixed because my warranty…Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 60,000 miles.

What to check before you buy

• On the test drive, press the gas gently and firmly. The response should be smooth with no lag or surge.
• Set the cruise control, then use resume and cancel to make sure each one works.

Tools that help

What owners said

The contact owns a 2016 Kia Sorento. The contact stated that while driving at undisclosed speeds, the check engine warning light intermittently illuminated and while coming to a stop, the oil warning light illuminated while the brake pedal was depressed. The contact stated that on several occasions, upon start up, the vehicle lost power…Owner complaint, filed 2023, at 107,000 miles

The contact owns a 2016 Kia Sorento. The contact stated that while driving approximately 65 MPH, the vehicle lost motive power and stalled. Later after restarting the vehicle, the vehicle would not exceed 20 MPH. The vehicle was inspected by an independent mechanic who diagnosed that the throttle body to the accelerator pedal was faulty…Owner complaint, filed 2023, at 120,000 miles

Half of the owners who gave a mileage had the problem by about 68,000 miles.

What to check before you buy

• Smell around the engine bay and under the rear of the car for raw fuel.
• On the test drive, accelerate firmly from a stop and up a grade. Stumbling, surging or a flashing check engine light are red flags.
• Fuel pump recalls are common. Check this exact VIN for open recalls before you buy.

Tools that help

What owners said

The contact owns a 2016 Kia Sorento. The contact stated that while driving at 65 MPH, there was an abnormally strong fuel odor inside the vehicle. The contact stated that while the vehicle was at the dealer for a scheduled service, the contact requested that the dealer inspect the issue. The vehicle was diagnosed with a low-pressure fuel…Owner complaint, filed 2026, at 79,000 miles

Check engine light came on again after recall for engine bearing failure and engine block was determined to qualify for replacement by home Kia dealer , est July / August 2024 in North Hampton NH . After motor block changes the engine light came on and off while in Florida vacationing . Today’s date is February 17 , 2025 and my vehicle…Owner complaint, filed 2025

Half of the owners who gave a mileage had the problem by about 54,000 miles.

What to check before you buy

• The pedal should feel firm and the car should stop straight without pulling, grinding or a pulsing pedal.
• The ABS and stability control lights should go out after startup and stay out.
• Look through the wheels at the rotors. A deep lip on the edge means brakes are due soon, which is a fair thing to negotiate on.

Tools that help

What owners said

The electric power brake (EPB) on my vehicle had a fault three separate times. The first time, the rear brakes were engaged by the EPB for approximately a half an hour. The second time a few weeks later, they stayed locked for approximately one hour. A few weeks after that, the brake locked up while the car was parked, and would not…Owner complaint, filed 2025

My cars shift lock release keeps getting stuck. I replaced the shift solenoid but that didn't work. I see there was a recall for 2016 kia sorentos for this issue but my VIN was not included in the recall. Can you direct on where I can go from here please! Thank youOwner complaint, filed 2025

Half of the owners who gave a mileage had the problem by about 59,000 miles.

What to check before you buy

• The air bag (SRS) light should come on at startup and go out within a few seconds. If it stays on, the system may not work in a crash.
• Air bag recalls are some of the most serious. Check this exact VIN for open recalls and get proof any recall work was done.

Tools that help

What owners said

Dear Kia America Customer Care Team, Thank you for your response regarding Case Number While I understand that my vehicle is technically outside the standard factory warranty period, I am formally requesting a managerial review of this decision. This is not a request for a cosmetic repair, but a critical safety concern regarding a…Owner complaint, filed 2026

The contact owned a 2016 Kia Sorento. The contact stated that while stopped at a red light, the signal turned green and they proceeded through the intersection when another driver ran the red light and collided with the vehicle. The impact occurred on the right rear passenger side, extending from the back door to the rear wheel well. no…Owner complaint, filed 2026, at 180,000 miles

Half of the owners who gave a mileage had the problem by about 10,000 miles.

What to check before you buy

• Pull out and latch every seat belt, and let each one retract on its own.
• Try every seat adjuster, and watch for a passenger air bag "off" light when an adult is in the seat.

Tools that help

What owners said

We bought a used 2016 Kia Sorrento. Upon driving, we realized that the seat belts were not tightening up on the driver's seat. We took the car into Kia in order to get the seat belt fixed. They told us it was the seat belt tentioner was bad and that the repair would not be covered under any kind of warranty. I called Kia directly to ask…Owner complaint, filed 2023

This model has 3 rows of seats. The 3rd row is pulled to the upright position from the back hatch access door. However, there does not appear to be a logical way to get to this 3rd row of seating without physically crawling on hands and knees. What am I missing ?Owner complaint, filed 2018

Parts named most: Blind spot detection (5).

What to check before you buy

• Where it is safe, try the adaptive cruise and lane keeping on the test drive and watch for sudden braking or warnings with nothing there.
• Check the windshield in front of the camera and the bumper sensors for cracks, chips or poor repairs.
• Ask whether the windshield has been replaced. The camera has to be recalibrated afterward, and many shops skip it.

Tools that help

What owners said

2016 kia sorento. Consumer writes in regards to vehicle "forward collision warning" system issues. *smd the consumer stated the forward collision warning system does not apply the brakes automatically in a near crash situation and the system may not provide a warning with enough time to help avoid a crash. The consumer stated the warning…Owner complaint, filed 2015

The red steering wheel with an exclamation point pops up on the dashboard and instantly I lose power steering the wheel gets really hard, it went out as I was making a turn and I almost hit the truck . I had to yank the wheel really hard to control the steering, then had to pull over turn the truck off then back on to reset the problem.…Owner complaint, filed 2025

Half of the owners who gave a mileage had the problem by about 44,000 miles.

What to check before you buy

• Drive over a few bumps and potholes slowly with the radio off and listen for clunks or rattles.
• Check the tires for uneven wear on the inside or outside edges, a sign of alignment or suspension trouble.
• Look behind the wheels for oily, wet shocks or struts.

Tools that help

What owners said

The contact owns a 2016 Kia Sorento. The contact stated that while driving 30 MPH, the vehicle made an abnormal cranking and popping sound. Upon researching the failure online, the contact learned that the vehicle was unsafe to drive. The contact associated the failure with NHTSA Campaign Number: 16V480000 (Suspension); however, the VIN…Owner complaint, filed 2026, at 93,000 miles

Rear control arm weld broke drivers side. 18 year old lost control on interstate at 70 miles per hour. Was spinning around and avoiding hitting a steal fence, steal beam and wall. I have pictures of the broken weld. If no recall yet their needs to be before it kills someone!! [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF…Owner complaint, filed 2023

What to check before you buy

• Read the four-digit DOT date on each tire. Tires older than about six years should be replaced, whatever the tread looks like.
• Check tread depth on all four. On AWD vehicles all four tires should match.
• The tire pressure light should go out after startup.

Tools that help

What owners said

Unusually rapid tire wear on front tires is going to require the 2nd [VIN] of all 4 tires within a 13 month period covering a total of 16,440 miles. The vset ofehicle was purchased used with new set of tires in 9/2018 (22,205 mi), by 3/2019, (31,648 mi) two tires were bald and required [VIN] of all 4 tires as car has all-wheel-drive..…Owner complaint, filed 2019, at 38,650 miles

All 4 tires on 2016 kia sorento are dry rotting at very fast pace. The tires are michel8n premier ltx 235 55/r19 m&s which should last 60,000 miles. I am at 39,600 at current time. Dry rot is very apparent on each tire. I bought this vehicle brand new w tires as noted on it at kia dealership in newport news va in 2016.Owner complaint, filed 2019