2019 Toyota Tundra Problems

Half of the owners who gave a mileage had the problem by about 80,000 miles.

What to check before you buy

• Smell around the engine bay and under the rear of the car for raw fuel.
• On the test drive, accelerate firmly from a stop and up a grade. Stumbling, surging or a flashing check engine light are red flags.
• Fuel pump recalls are common. Check this exact VIN for open recalls before you buy.

Tools that help

What owners said

The fuel pump and the fuel pump control module system failed. Before the failure, I drove my 2019 Toyota Tundra on XXX from [XXX] to [XXX] with no prior check engine light warning. It was parked for all 3 days at a campground in [XXX]. However, on XXX the vehicle would not start. The truck ignition was moved to the RUN position and then…Owner complaint, filed 2026

We had just exited the interstate when my Toyota Tundra stopped. We had it towed to the closest Toyota dealer. We had to have fuel pump replaced. They said the previous year Tundra was recalled for this issue, but ours was not. I just found out that some of the 2019 models had been recalled for this issue. They said my VIN was not…Owner complaint, filed 2026

Half of the owners who gave a mileage had the problem by about 15,000 miles.

What to check before you buy

• Test every switch: windows, locks, mirrors, seat heaters, the screen, the backup camera, Bluetooth and every USB port.
• Watch the dash at startup. Every warning light should come on briefly and then go out.
• Have the battery and charging system tested. A weak alternator or battery drain shows up here.

Tools that help

What owners said

2019 Tundra: for no reason or indication the vehicle displayed a “Trailer Break Error” and “Pre-collision System malfunction” warning asking me to pull over if towing anything (nothing was being towed) and to contact the dealership. Vehicle still operational however the menus can’t be seen as the warning is consistent.Owner complaint, filed 2023

The contact owns a 2019 Toyota Tundra. The contact stated that while parked for 5-10 minutes, the contact noticed a burning plastic odor, and upon looking up moments later, the contact noticed flames coming from the driver's side headlight, and the flames were 6 inches above the headlight. The contact started extinguishing the fire with…Owner complaint, filed 2026, at 100,500 miles

Parts named most: Warnings (10).

What to check before you buy

• Where it is safe, try the adaptive cruise and lane keeping on the test drive and watch for sudden braking or warnings with nothing there.
• Check the windshield in front of the camera and the bumper sensors for cracks, chips or poor repairs.
• Ask whether the windshield has been replaced. The camera has to be recalibrated afterward, and many shops skip it.

Tools that help

What owners said

Pre collison warning system has turned itself off in the rain and states visit dealer for service. Never logs data and on when you get to dealer. Same system has also flash "Brake" on the highway at 65 mph when a dry sunny day and no cars around. I am worried it may actually brake by accident causing loss of control. Went to dealer on…Owner complaint, filed 2021

Toyota Safety Sense (TSS) malfunctions sporadically while driving. Warning lights illuminate and Dynamic Radar Cruise Control (DRCC) disengages when activated while driving. The Pre-Collision System (PCS) is turned off and flashes with the following error messages. - Pre-Collision System Malfunction - Visit Your Dealer - Auto Headlight…Owner complaint, filed 2021

What to check before you buy

• The pedal should feel firm and the car should stop straight without pulling, grinding or a pulsing pedal.
• The ABS and stability control lights should go out after startup and stay out.
• Look through the wheels at the rotors. A deep lip on the edge means brakes are due soon, which is a fair thing to negotiate on.

Tools that help

What owners said

The contact owns a 2019 Toyota Tundra. The contact stated that while replacing the shocks, the contact noticed that the shocks were oily. The vehicle was taken to the local dealer for warranty repair, and the contact was informed that the brake pads on the rear axle were soaked with oil. The vehicle was not repaired. The manufacturer was…Owner complaint, filed 2025, at 30,000 miles

Driving at 55 MPH on a dark road with no shoulder when the truck began shaking violently in the middle of a banker left turn. Had driven approximately 2 miles from home when problem suddenly occurred. Overwhelming smell of burning brakes outside when I opened the door and the rear driver side wheel was hot. Truck towed to dealership the…Owner complaint, filed 2020, at 5,000 miles

Half of the owners who gave a mileage had the problem by about 5,000 miles.

What to check before you buy

• Check every light: headlights on low and high, fog lights, brake lights, turn signals and reverse lights.
• Run the wipers on every speed with washer fluid, and run the defroster front and back.

Tools that help

What owners said

Factory installed OEM LED HEADLIGHTS: While driving in WET SNOW and SNOW conditions, headlights get covered in snow and visibility is greatly reduced to almost zero.Owner complaint, filed 2024

The contact owns a 2019 toyota tundra. While driving approximately 70 MPH, an explosion was heard. The vehicle was pulled over and the contact noticed that the sun roof exploded without an impact or warning. There were no injuries. The contact called oakbrook toyota at 630-789-9600 (located at 550 e ogden ave, westmont, il 60559) and was…Owner complaint, filed 2019, at 4,800 miles

What to check before you buy

• Look underneath with a flashlight. Utah road salt is hard on frames, brake lines and the bottoms of doors.
• Open and close every door, the hood and the liftgate, and lock and unlock each one.
• Use a paint thickness gauge and compare panels. A panel that reads very differently from the rest has likely been repaired.

Tools that help

What owners said

Sunroof shattered while driving on highway. Noise similar to a gun being fired, caused momentary disorientation; however, was able to keep vehicle on the road. No warning, no other vehicles around that could have kicked up a rock, debris, etc. Smooth conditions on the road (no potholes, bumps, etc.). Sunroof was in the tilt up position…Owner complaint, filed 2022

The contact owns a 2019 toyota tundra. While the contact was loading wood into the vehicle, the bed caved in on the vehicle. Shortly after, the tailgate fractured. The body of the vehicle could be pushed in by hand. The vehicle was taken to l and s toyota (248 auto plaza drive, beckley, wv 25801, (304) 252-8548) where it was diagnosed…Owner complaint, filed 2019, at 2,000 miles

What to check before you buy

• Turn the wheel lock to lock while parked and listen for groaning, clicking or binding.
• On a straight road the car should track straight with the wheel centered and no loose feeling.
• A power steering warning on the dash, even briefly, deserves a mechanic’s look before you buy.

Tools that help

What owners said

I had to have the steering rack assembly replaced in my vehicle due to a leak. This is one of the complaints and a recall but I never got a notification.Owner complaint, filed 2025

My son was driving to Mineral Wells to get something to eat on Wednesday 11/17/21 at 8:00 at night on FM 52 South. All of a sudden the steering wheel falls in his lap. He picked it up and shoved it onto the column and was able to steer the truck onto the side of the road without hitting anything. He looked underneath the steering wheel…Owner complaint, filed 2021

What to check before you buy

• The air bag (SRS) light should come on at startup and go out within a few seconds. If it stays on, the system may not work in a crash.
• Air bag recalls are some of the most serious. Check this exact VIN for open recalls and get proof any recall work was done.

Tools that help

What owners said

The contact owned a 2019 Toyota Tundra. The contact stated that while driving at approximately 45 MPH, an oncoming vehicle did not obey a stop sign and proceeded to crash into the rear driver's side of the contact's vehicle. As a result, the contact lost control of the vehicle and crashed into the platform of an 18-wheeler. No air bags…Owner complaint, filed 2024, at 75,000 miles

The contact owns a 2019 Toyota Tundra. The contact stated that while driving approximately 75 mph, a 2008 Lincoln struck the rear passenger side of her vehicle which caused her vehicle to tail spin and crash into the guardrail. The vehicle continued to tailspin. The air bags did not deploy. All the warning indicator lights were flashing…Owner complaint, filed 2023, at 80,000 miles

What to check before you buy

• Read the four-digit DOT date on each tire. Tires older than about six years should be replaced, whatever the tread looks like.
• Check tread depth on all four. On AWD vehicles all four tires should match.
• The tire pressure light should go out after startup.

Tools that help

What owners said

275/55r20. only have around 10,000 miles. just rotate the tire at Walmart in Texas . on my way to Georgia my rear tire exploded without any warning at 75 mph . I almost lost control over the vechle .Owner complaint, filed 2024

I took my vehicle in for scheduled maintenance. During the safety inspection the Toyota authorized tech advised me about a serious safety issue with rust on the undercarriage of my vehicle. He advised that the control arms as well as sway bars and suspension , shocks, struts had heavy rust on them. He advised that this is a safety issue…Owner complaint, filed 2023

What to check before you buy

• Ask the seller not to warm the car up, and start it cold. Listen for ticking, knocking or a rough idle in the first minute.
• Pull the oil dipstick and the oil cap. Low oil, a gasoline smell or a milky film on the cap are reasons to walk away or get an inspection.
• Plug in an OBD2 scanner. Stored or pending codes matter, and so do readiness monitors that show "not ready", which usually means the codes were cleared right before the sale.
• Ask for oil change records. A gap in the records on a model known for engine complaints is a negotiating point at minimum.

Tools that help

What owners said

Having fuel pump issue. Car stalls very badly and pre collision light and engine lights start flashing. Severe jumping by car driving down the road. When accelerating the car has no acceleration and hesitates very badly.Owner complaint, filed 2025

3 times in the last few mos the BRAKE! warning came on. Nothing was causing this warning to engage. This happened again today. Another issue is when the Valdosta Toyota (GA) dealer attempted to fix the fuel pump recall on 22 JUL 2020 it was assembled incorrectly. I called the dealership and told them to come and get my Tundra because gas…Owner complaint, filed 2021

What to check before you buy

• Drive over a few bumps and potholes slowly with the radio off and listen for clunks or rattles.
• Check the tires for uneven wear on the inside or outside edges, a sign of alignment or suspension trouble.
• Look behind the wheels for oily, wet shocks or struts.

Tools that help

What owners said

Rear axles aren't the proper fit, causing them to shake which causes the rotors to vibrate that produces an squeaky/stretching noise when braking. Was originally told it was normal until I contacted toyota customer care. Service techs states that 'it's safe to drive' but I didn't trust it. My truck isn't the only truck, there are serval…Owner complaint, filed 2019

I took my vehicle in for scheduled maintenance. During the safety inspection the Toyota authorized tech advised me about a serious safety issue with rust on the undercarriage of my vehicle. He advised that the control arms as well as sway bars and suspension , shocks, struts had heavy rust on them. He advised that this is a safety issue…Owner complaint, filed 2023

What to check before you buy

• On the test drive, press the gas gently and firmly. The response should be smooth with no lag or surge.
• Set the cruise control, then use resume and cancel to make sure each one works.

Tools that help

What owners said

While driving 40 MPH the warning light 'accelerator and brake pedals depressed simultaneously ' came on and the truck slowed down significantly, which almost caused an accident. The brake pedal was not being used while driving.Owner complaint, filed 2019, at 4,000 miles

While driving with the adaptive cruise control set a message will appear "radar cruise control unavailable clean sensor". This message will appear with no adverse weather conditions. Due to this error the cruise control no longer works and the pre-collision warning system no longer works. Also randomly a "brake!" message will appear and…Owner complaint, filed 2019, at 5,233 miles

What to check before you buy

• Pull out and latch every seat belt, and let each one retract on its own.
• Try every seat adjuster, and watch for a passenger air bag "off" light when an adult is in the seat.

Tools that help

What owners said

I was on a camping trip in Wyoming, and I started my Tundra up on a chilly morning. It was running for about 5 minutes before I came back to it and entered the cab. Immediately upon entering I noticed a strange smell. I also noticed at that time that the driver’s seat was extremely warm. I quickly shut off the heat warmer (original…Owner complaint, filed 2023

The seat heater control module has failed causing the plastic to burn and melt, nearly starting a fire. Toyota knows about this but refuses to issue a safety recall.Owner complaint, filed 2023

What to check before you buy

• Drive it from cold if you can. Shifts should be smooth in every gear, including reverse.
• Feel for slipping (revs rise without the car speeding up), shudder at low speed and a delay when you put it in gear.
• Listen for whining, which is a common CVT complaint, and clunks when you go from drive to reverse.
• If it has 4WD or AWD, engage it on the test drive and ask when the transmission and differential fluids were last changed.

Tools that help

What owners said

Vehicle parked on boat launching ramp 25-30% slope concrete surface with 24 foot aluminum trailer in tow; boat off trailer, truck facing away from water, trailer closest to water. Sunny, ramp was damp, with some wood and aquatic vegetation on ramp. Vehicle was in 2 wheel drive. After unloading boat using a launch cord and pulling boat…Owner complaint, filed 2019, at 5,500 miles